 |
Material Safety Data Sheet |
 |
| Mirachem® 750 Low Foam Cleaner / Degreasergreasergreaser |
(Formulation No. 2750) |
Section I - Chemical Product and Company Identification
|
Manufacturer Name: Mirachem Corporation P.O. Box 14059 Phoenix, Arizona 85063-4059
Emergency
Phone: 1-(800) 847-3527 |
Date
Prepared: 11/03/94 |
Section II - Composition/Information on Ingredients
|
Hazardous Component (CAS #) |
OSHA PEL |
ACGIH TLV |
Other Limits |
% (Optional) |
|
None |
|
|
|
|
Section III - Hazards Identification
| Emergency Overview: | Clear, non-flammable, water based cleaner with a light detergent odor. |
| Potential Health Effects: | |
| Eye Contact: | May cause mild temporary irritation. |
| Skin Contact: | Prolonged or repeated exposure may cause mild irritation. |
| Inhalation: | No adverse effects expected. |
| Ingestion: | No adverse health effects are anticipated to occur as a result of acute ingestion. Chronic effects are not known. |
| Carcinogenicity: | None of the components in this material are listed by IARC, NTP, OSHA, or ACGIH as a carcinogen. |
| Signs/Symptoms of Overexposure: | Prolonged contact may cause mild irritation or dryness to sensitive skin. |
| Medical Conditions Generally Aggravated by Exposure: | None known. |
Section IV - First Aid Measures
| Eyes: | Immediately flush with clean water. Consult physician if necessary. |
| Skin: | Rinse with water. |
| Ingestion: | If swallowed, treat symptomatically and supportively. Do not induce vomiting. If victim conscious and alert, give two glasses of water or milk to drink. If vomiting occurs, keep head below hips to prevent aspiration. Contact Physician. |
| Inhalation: | No adverse effects anticipated. |
Section V - Fire and Explosion Hazard
|
Flash Point (Method Used): |
>212ºF (PMCC, nonflammable) |
Explosive Limits: |
N/A |
|
|
Extinguishing Media: |
N/A |
|||
|
Special Fire Fighting Procedures: |
N/A |
Unusual Fire Fighting and Explosion Hazards: |
N/A |
|
Section VI - Accidental Release
| Small Spills: | Flush with water into containing area or to sewer where applicable within Federal, State or Local disposal requirements. |
| Large Spills: | Dike and pump into suitable containers, clean up residual with absorbent material and wash with water. Dispose of in accordance with Federal, State or Local disposal requirements. |
Section VII - Handling & Storage
| Handling & Storage Precautions: | Wear protective goggles or face shield if splashing or spraying liquid. Protect from freezing. |
| Other Precautions: | Keep container tightly closed. Keep out of reach of children. |
Section VIII - Exposure Controls, Personal Protection
| Respiratory Protection: | No respiratory protection is necessary. |
| Ventilation: | Good general ventilation is sufficient. |
| Protective Clothing: | When prolonged skin contact is expected, wear protective gloves. |
| Eye Protection: | Wear safety glasses. |
| Work/Hygienic Practices: | Use good personal hygiene practices, wash hands before eating, drinking, smoking, or using toilet facilities. |
Section IX - Physical/Chemical Characteristics
|
Boiling Point: |
>210ºF |
Specific Gravity (H2O = 1): |
.995 |
|
Vapor Pressure (mm Hg.) @ 20ºC |
Composite = 0.001 |
pH: |
9.5-10.0 |
|
Vapor Density (AIR =1): |
> 1 |
Evaporation Rate (Butyl Acetate = 1): |
> 1 |
| Solubility in Water: |
Complete |
Melting Point: |
N/A |
|
Appearance and Odor: |
Clear liquid with a mild detergent odor | ||
|
N/A = Not Applicable N.E. = Not Established |
|||
Section X - Stability & Reactivity
| Stability: | Unstable X Stable |
| Incompatibility (Materials to Avoid): | Strong reducing agents |
| Hazardous Decomposition or By-products: | Thermal decomposition may produce CO2 |
| Hazardous Polymerization: | May Occur X Will Not Occur |
Section XI - Toxicological Information
| This product has not been tested on animals or on humans. Invitro toxicity results on the final product are as follows: | |
| Corrositex: | Packing group test results rate this product as non-corrosive (>60 minutes) |
Section XII - Ecological Information
Section XIII - Disposal Considerations
|
Waste Disposal: (Unused Material) |
Flush uncontaminated material to sewer where applicable within Federal, State or Local disposal requirements. |
| Note: Chemical additions to, processing of, or otherwise altering this material may make this waste management information incomplete, inaccurate, or otherwise inappropriate. Furthermore, State and local waste disposal requirements may be more restrictive or otherwise different from Federal laws and regulations. | |
Section XIV - Transportation Information
|
D.O.T Shipping Name: |
Not Regulated |
D.O.T Hazard Class: |
None |
|
UN Shipping Name: |
N/A |
UN/NA Number: |
N/A |
|
UN Class or Division |
N/A |
UN Packing Group: |
None |
|
NMFC Freight Class |
Compound, Cleaning Fluid, NOI 48580 Sub 3 |
||
Section XV - US Regulatory Information
Notice: The information herein is presented in good faith and believed to be accurate as of the effective date shown above. However, no warrantee, express or implied is given. Regulatory requirements are subject to change and may differ from one location to another; it is the buyer's responsibility to ensure that its activities comply with federal, state, and local laws. The following specific information is made for the purpose of complying with numerous federal, state, and local laws and regulations.
Federal Regulations:
| Workplace Classification | This product is considered non-hazardous under the OSHA Hazard Communication Standard (29CFR 1910.1200) |
| SARA Title III | |
| Section 311/312 | This product is not a hazardous chemical under 29CFR 1910.1200, and therefore is not covered by Title III of SARA. |
| Section 313 | This product does not contain a chemical, which is listed in Section 313 at or above de minimis concentrations. |
|
CERCLA Information (40CFR 302.4) |
Releases of this product to air, land, or water are not reportable to the National Response Center under the Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA) or to state and local emergency planning committees under the Superfund Amendments and Reauthorization Act (SARA) Title III Section 304. |
| Waste Classification |
When a decision is made to discard unused portions of this product, it does not meet RCRA’s characteristic definition of ignitability, corrosivity, or reactivity, and none of the materials used in this product are listed in 40 CFR 261.33. The toxicity characteristic (TC), however, has not been evaluated by the Toxicity Characteristic Leaching Procedure (TCLP). Note: Chemical additions to, processing of, or otherwise altering this material may make this waste management information incomplete, inaccurate, or otherwise inappropriate. Furthermore, State and local waste disposal requirements may be more restrictive or otherwise different from Federal laws and regulations. |
| TSCA | All components of this product are in compliance with the inventory listing requirements of the U.S. Toxic Substances Control Act. |
|
NFPA Ratings |
Health = 1 |
Flammability = 0 |
Reactivity = 0 |
Special = 0 |
|
NPCA-HMIS Ratings |
Health = 1 |
Flammability = 0 |
Reactivity = 0 |
Protective Equipment = None |
Arizona
| Maricopa County | Under the definitions of Rule 331, this product is considered a Low-VOC Cleaner. |
|
California
Safe Drinking Water and Toxic Enforcement - Prop. 65 |
This product does not contain any materials currently listed by California as chemicals known to cause cancer or known to have reproductive toxicity under Proposition 65. |
| Volatile Organic Compounds (VOC) | The VOC content of this product is 75 grams/Liter (0.62 pounds/gallon) with a composite partial pressure at 20°C of less than 1 mm Hg. |
| SCAQMD | This product, when used at normal use dilutions of 2:1 or greater is certified by the South Coast Air Quality Management District as a Clean Air Solvent (CAS). The VOC content at a 2:1 dilution as determined by SCAQMD is 25 g/L (0.21 lbs./gal.) with a composite partial pressure at 20°C of less than 1 mm Hg. |
Section XVI - International Regulatory Information
Notice: The information herein is presented in good faith and believed to be accurate as of the effective date shown above. However, no warrantee, express or implied is given. Regulatory requirements are subject to change and may differ from one location to another; it is the buyer's responsibility to ensure that its activities comply with their federal, state/province, and local laws. The following specific information is made for the purpose of complying with numerous specific foreign regulations.
| Australia | This product is not classified as hazardous according to criteria of Worksafe Australia. Mirachem has reviewed Australia's List of Hazardous Substances and Australia's Standard of the Uniform Scheduling of Drugs and Poisons and determined that no ingredient in this product is listed in either listing. We have also verified with NICNAS at the Australian National Occupational Health & Safety Commission (NOHSC) that all of the components in this formulation are listed in the Australian Inventory of Chemical Substances (AICS) and that no notification will be necessary under the Industrial Chemicals (Notification and Assessment) Act 1989. |
| Canada | Non-controlled under WHMIS. All of the components in this product are listed in the Canadian “Domestic Substances List” (DSL). |
| European Union | All materials in this formulation are listed in the “European Inventory of Existing Commercial Chemical Substances” (EINECS). This product is not a hazardous preparation according to the EC-Directive 88/379/EEC. |
| Korea | All materials in this formulation are listed in the Korean "Existing Chemcials List" (ECL). No material in this product is made from animal by-products. |
| Philippines | All materials in this formulation are listed in the "Philippines Inventory of Chemcials and Chemical Substances" (PICCS). |
| Japan | All materials in this formulation are listed in Japan's Inventory of "Existing and New Chemcial Substances" (ENCS). |
